Soy Protein Isolate and Gum Arabic Composite Affects Stability of Beverage Emulsion.

The aim of the present work was to evaluate the effect of soy protein isolate (spi)-gum arabic (ga) composite on the stahility of beverage emulsion prepared as the orange oil-in-water (o/w) emulsion. response surface methology (rsm) was used to study the influence of the two independent variables, each at three levels (homogenization speedas x1 (1500, 15700, and 30000 rpm) and ga:spi ratio as x2 (1, 0.6, and 0.2) on the two dependent variables namely , size of the emulsion droplet (eps) as y1 and emulsifying activity (ea) as y2. the results were discussed on the two empirical models obtained. analysis of variance (anova) showed a high coefficient of determination (r^2) value of 0.937 and 0.979 for eps and ea, respectively, ensuring a satisfactory adjustment of the second-order regression model with the experimental data. the negative sign for the regression coefficient of x1, indicated that size of the emulsion droplet increased with the decreased level of factor x1 from 30000 to 1500 rpm, while ea increased withincreased levels of factor x1.thus, ga: spi ratio with the lowest amount of ga along with the homogenization speed at high level, gave the smallest size of emulsion droplet (1 (mu)m). this size corresponded to the high emulsifying activity and stability. sodium chloride and freeze- thaw cycling are two environmental factors affecting emulsion stability. results of freeze-thaw cycling test showed a large decrease in the ea of the sample prepared with a low level of spi:ga ratio and no dependence of the ea on the naci concentrations in the range of the tested levels was observed (50-150 mm). longterm storage stability test (storing the emulsion samples at 4, 16, and 30 °c each for 8 days) showed the size of the emulsion droplet increased with the storage time. results of use of spi as a readily available plant source of protein for preparation of the encapsulant for orange oil-emulsion were encouraging, especially when one considers the dependence of the beverage industry on the unreliable source of supply of ga. rsm was successfully applied for the modeling of the emulsion preparation.