>
Fa   |   Ar   |   En
   مطالعه تاثیر تشکیل ناحیه میان‌فازی بر روی خواص الکتریکی پوشش‌های اپوکسی حاوی نانوصفحات اکسید گرافن احیا شده  
   
نویسنده نامور آمقانی امیررضا ,رضوانی مقدم امیر ,سلامی کلجاهی مهدی ,رنجبر زهرا
منبع علوم و فناوري رنگ - 1402 - دوره : 17 - شماره : 1 - صفحه:77 -91
چکیده    در این مقاله با تغییر میزان اکسید شدن سطحی اکسید گرافن ضخامت ناحیه میان‌فازی تغییر داده شد و به بررسی اثر این ناحیه بر روی خواص رسانایی پرداخته شد. به دلیل شباهت شیمیایی مناسب رزین اپوکسی پایه آب مورد استفاده با گروه‌های اکسیژنی اکسید گرافن، ناحیه میان‌فازی بین پلیمر نارسانا و پرکننده رسانا تقویت گردید. طیف‌سنجی زیر ‌قرمز و وزن‌سنجی حرارتی به منظور بررسی موفقیت‌آمیز بودن اکسید شدن گرافن و همچنین طیف‌سنجی رامان به منظور بررسی نقص ساختاری به وجود آمده بر روی صفحات اکسید گرافنی، انجام شدند. در دید اول، با تکیه بر تئوری ناحیه میان‌فازی انتظار می‌رود که با افزایش میزان اکسید شدن نانوصفحات گرافن، رسانایی الکتریکی پوشش‌های پلیمری افزایش و آستانه فراگیری کاهش یابد. از طرف دیگر، با افزایش اکسید شدن، نقص ساختاری بر روی نانوصفحات اکسید گرافنی افزایش می‌یابد که به تبع آن انتظار می‌رود رسانایی پوشش‌ها با افزایش میزان اکسید شدن اکسید گرافن کاهش یابد. در این تحقیق سعی برآن است تا با توجه به تاثیر متضاد دو عامل ذکرشده، میزان تاثیرپذیری نمونه‌های نانوکامپوزیتی مطالعه و اثرگذاری هر کدام از عوامل مختلف بررسی شود.
کلیدواژه ناحیه میان‌فازی، نانوصفحات گرافنی، اپوکسی پایه آب، رسانایی الکتریکی
آدرس دانشگاه صنعتی سهند, دانشکده مهندسی پلیمر, ایران, دانشگاه صنعتی سهند, دانشکده مهندسی پلیمر، پژوهشکده مواد پلیمری, ایران, دانشگاه صنعتی سهند, دانشکده مهندسی پلیمر، پژوهشکده مواد پلیمری, ایران, پژوهشگاه رنگ, گروه پژوهشی سطح و خوردگی, ایران
پست الکترونیکی ranjbar@icrc.ac.ir
 
   role of interphase region on electrical conductivity of epoxy-reduced graphene oxide nanocomposites  
   
Authors namvar amghani amirreza ,rezvani moghaddam amir ,salami-kalajahi mehdi ,ranjbar zahra
Abstract    by varying the level of graphene’s surface oxidation in this paper, the thickness of the interphase region was altered, and its influence on the conductivity was investigated. due to the similarity of water-based epoxy chemical groups with graphene oxide oxygen groups, the interphase region was reinforced. infrared spectroscopy and thermal gravimetry were performed to evaluate the graphene oxide synthesis, and raman spectroscopy was also performed to investigate the structural defects on graphene sheets. at first glance, based on the interphase region theory, it is expected that by increasing the oxidation rate of graphene nanosheets, the electrical conductivity of polymeric coatings will increase, and the percolation threshold will decrease. on the other hand, due to increased oxidation, the structural defect on graphene nanosheets increases, and the conductivity of the coatings is expected to decrease. due to the opposite effect of the two factors mentioned above, the effectiveness of nanocomposite samples was studied, and the impressment of each factor was investigated in this project.
Keywords interphase region ,graphene nanosheets ,waterborne epoxy resin ,electrical conductivity
 
 

Copyright 2023
Islamic World Science Citation Center
All Rights Reserved